Abstract Excessive use of chemical insecticides to control Spodoptera frugiperda in maize (Zea mays L.) crops in Colombia has resulted in pest resistance and environmental contamination. A Colombian multicapsid nucleopolyhedrovirus (SfMNPV) was produced in laboratory reared larvae and formulated as a wettable powder by microencapsulating the viral occlusion bodies (OBs) with a methacrylic acid polymer. Microencapsulated OBs were tested for insecticidal activity in laboratory, greenhouse and field bioassays, and were then sprayed onto a commercial crop where their effect on arthropod populations was estimated. In laboratory bioassay, microencapsulated and non-microencapsulated OBs caused a larval mortality of 98 and 96%, respectively. The percent of plants showing recent feeding damage in a greenhouse experiment oscillated between 2.5 and 7.5% when OBs were applied compared to 70% observed in the control. In two field trials, the highest dose of 1.5×1012 OBs/ha (1500 g/ha) was selected as the recommended rate for field application in maize crops, with efficacies higher than 70%. Total arthropod populations were negatively affected by chemical pesticides; whereas the OBs formulation did not affect the diversity of these organisms. Our results indicate that microencapsulated SfMNPV has the potential to be commercialised as an alternative to substitute or complement chemical insecticides in fall armyworm integrated management programmes.